Aerko International
3410 NE 5th Avenue, Oakland Park, Florida 33334
MATERIAL SAFETY DATA SHEET
DATE OF PREPARATION: May 15, 1991 EMERGENCY TELEPHONE #: (305) 565-8475
UPDATED: March 22, 2005 AFTER HOURS 800-424-9300
SECTION I: PRODUCT IDENTIFICATION
Product Name: STREAMER Training Units
Product Number: 1/2 OZ, 2OZ, 3/4 OZ 4OZ.
Product Class: Self Defense Spray, Aerosol
D.O.T. Shipping Class: ORM-D Consumer Commodity
SECTION II: HAZARDOUS INGREDIENTS
OCCUPATIONAL
INGREDIENT PERCENT EXPOSURE LIMITS VAPOR PRESSURE
TLV PEL
CONFIDENTIAL
A-70 1000 PPM 1000 PPM 46 PSIG @ 70o F
SECTION III: PHYSICAL DATA
Boiling Range: 2120F
Vapor Density: 2.1 (air=1) Heavier than air
Percentage Volatile by weight: 100%
Evaporation Rate: 2.0 (Butyl Acetate=1)
Weight per gallon: 8 lbs.
Specific Gravity: 1.0 @ 60o F
Appearance: Clear Liquid
Odor: None
SECTION IV: FIRE AND SAFETY EXPLOSION HAZARD DATA
Flammability Classification OSHA: Non-Flammable
Shipping Classification D.O.T.: ORM-D
Flash Point: Non Flammable
Flammable Levels in Air: Lower: >2.5 Upper: 12.0
Extinguishing Media: Foam, Water, CO2, Dry Chemical
Unusual Fire and Explosion Hazards: Do not expose to heat or flame or store above 120o F as high internal pressures may cause leaking.
Special Fire Fighting Procedures: Full protective equipment including self contained breathing apparatus should be used, Fog nozzles should be used to cool closed containers to prevent pressure buildup. Move undamaged containers from fire area if accomplished without risk.
SECTION V: HEALTH HAZARD DATA
PRIMARY ROUTE (S) OF ENTRY: Dermal, Inhalation
EMERGENCY AND FIRST AID PROCEDURE
EYES: None, can contains only water propelled by volatile gas which does not contact the skin.
SKIN CONTACT: None.
INHALATION: Wintergreen Fragrance to simulate live units may cause sneezing.
PHYSIOLOGICAL EFFECTS AND HEALTH INFORMATION
EYE EFFECTS: This product is not a minor eye irritant. Water pressurized may cause watery eyes.
SECTION VI: REACTIVITY DATA
STABILITY: Stable
HAZARDOUS POLYMERIZATION: ill Not Occur
CONDITIONS TO AVOID: Heat, open flames, electrical and static discharges.
INCOMPATIBILITY (MATERIALS TO AVOID): Strong Acids, Alkalies and Oxidizers.
SECTION VII: SPILL OR LEAK PROCEDURES
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: Ventilate area. Remove all possible sources of ignition. Contains water. Confine spill with inert absorbent. Wear protective equipment during clean up.
WASTE DISPOSAL: Incinerate in an approved incinerator or dispose of in accordance with Local, State and Federal Regulations.
SECTION VIII: SAFE HANDLING AND USE INFORMATION
RESPIRATORY PROTECTION: None.
VENTILATION: None.
PROTECTIVE GLOVES: None.
SECTION IX: SPECIAL PRECAUTIONS
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING: Store in a cool dry area away from sources of ignition. When storing large quantities, store in building designed and protected against fire.
DO NOT STORE IN DIRECT SUNLIGHT OR ABOVE 120O F.
OTHER PRECAUTIONS: "FOR INDUSTRIAL USE ONLY" Do not take internally. If ingested, DO NOT INDUCE VOMITING. Consult a physician.
SECTION X: Hazardous Material Identification System
HEALTH
0-No Significant Health Risk
1-Irritation or Minor Reversible Injury Possible
2-Temporary or Minor Injury May Occur
3-Major Injury Likely Unless Prompt Action is Taken and Medical Treatment is Given
4-Life Threatening; Major Permanent Damage May Result from Single or Repeated Exposures
FLAMMABILITY
0-Materials Will Not Burn
1-Flash Point Above 200O F
2-Flash Point Above 100O F below 200O F
3-Flash Point Between 73O F and 100O F
4-Flash Point Below 73O F
PHYSICAL HAZARD
0-Material that are normally stable even under fire conditions and will not react with water.
1-Material that are normally stable but can become unstable (self-react) at high temperatures and pressures; may react non violently with water to undergo hazardous polymerization in the absence of inhibitions.
2-Materials that are unstable; may react violently with water and undergo violent chemical changes with low risk for explosion.
3-Materials that may for explosive mixtures with water or undergo other chemical change at normal temperatures.
4-Materials capable of explosive water reaction, decomposition or polymerization.
Streamer Trainer H.M.I.S.
Health: 0
Flammability: 0
Physical Hazard: 0
THE INFORMATION CONTAINED HEREIN IS BASED ON TECHNICAL DATA WHICH WE BELIEVE TO BE RELIABLE, HOWEVER, SINCE THE CONDITIONS UNDER WHICH THIS INFORMATION MAY BE APPLIED ARE BEYOND OUR CONTROL WE CAN ASSUME NO LIABILITY FOR RESULTS OF ITS APPLICATION. THIS INFORMATION SHOULD BE USED ONLY BY PERSONS HAVING SUFFICIENT TECHNICAL SKILL TO MAKE INFORMED JUDGEMENTS REGARDING ITS APPLICATION.
Aerko International
3410 NE 5th Avenue
Oakland Park, FL 33334