Aerko International

3410 NE 5th Avenue, Oakland Park, Florida 33334

MATERIAL SAFETY DATA SHEET

DATE OF PREPARATION: May 15, 1991      EMERGENCY TELEPHONE #: (305) 565-8475

UPDATED:  March 22, 2005        AFTER HOURS 800-424-9300

 SECTION I: PRODUCT IDENTIFICATION

Product Name:                                    STREAMER Training Units

Product Number:                                1/2 OZ, 2OZ, 3/4 OZ 4OZ.

Product Class:                                    Self Defense Spray, Aerosol

D.O.T. Shipping Class:                       ORM-D Consumer Commodity

SECTION II: HAZARDOUS INGREDIENTS

                                                                                                                 OCCUPATIONAL

INGREDIENT                                          PERCENT                  EXPOSURE LIMITS                  VAPOR PRESSURE

                                                                                                    TLV                           PEL

CONFIDENTIAL

A-70                                                                                           1000 PPM             1000 PPM             46 PSIG @ 70^o F

 SECTION III: PHYSICAL DATA

Boiling Range:                                                     212⁰F

Vapor Density:                                                     2.1 (air=1) Heavier than air

Percentage Volatile by weight:                       100%

Evaporation Rate:                                               2.0 (Butyl Acetate=1)

Weight per gallon:                                              8 lbs.

Specific Gravity:                                                  1.0 @ 60^o F

Appearance:                                                        Clear Liquid

Odor:                                                                      None

 SECTION IV: FIRE AND SAFETY EXPLOSION HAZARD DATA

Flammability Classification OSHA:                Non-Flammable

Shipping Classification D.O.T.:                        ORM-D

Flash Point:                                                          Non Flammable

Flammable Levels in Air:                                  Lower: >2.5     Upper: 12.0

Extinguishing Media:                                         Foam, Water, CO₂, Dry Chemical

Unusual Fire and Explosion Hazards:  Do not expose to heat or flame or store above 120^o F as high internal pressures may cause leaking.

Special Fire Fighting Procedures:  Full protective equipment including self contained breathing apparatus should be used, Fog nozzles should be used to cool closed containers to prevent pressure buildup.  Move undamaged containers from fire area if accomplished without risk.

SECTION V: HEALTH HAZARD DATA

PRIMARY ROUTE (S) OF ENTRY:  Dermal, Inhalation

EMERGENCY AND FIRST AID PROCEDURE

EYES:  None, can contains only water propelled by volatile gas which does not contact the skin. 

SKIN CONTACT:  None.

INHALATION:  Wintergreen Fragrance to simulate live units may cause sneezing.

 PHYSIOLOGICAL EFFECTS AND HEALTH INFORMATION

EYE EFFECTS:       This product is not a minor eye irritant.  Water pressurized may cause watery eyes.

SECTION VI: REACTIVITY DATA

STABILITY:                                                                            Stable

HAZARDOUS POLYMERIZATION:                                    ill Not Occur

CONDITIONS TO AVOID:                                                    Heat, open flames, electrical and static discharges.

INCOMPATIBILITY (MATERIALS TO AVOID):                 Strong Acids, Alkalies and Oxidizers.

SECTION VII: SPILL OR LEAK PROCEDURES

STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:  Ventilate area.  Remove all possible sources of ignition.  Contains water.  Confine spill with inert absorbent.  Wear protective equipment during clean up.

WASTE DISPOSAL:  Incinerate in an approved incinerator or dispose of in accordance with Local, State and Federal Regulations.

SECTION VIII: SAFE HANDLING AND USE INFORMATION

RESPIRATORY PROTECTION:  None.

VENTILATION:  None.

PROTECTIVE GLOVES:  None.

SECTION IX: SPECIAL PRECAUTIONS

PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING:  Store in a cool dry area away from sources of ignition.  When storing large quantities, store in building designed and protected against fire.

DO NOT STORE IN DIRECT SUNLIGHT OR ABOVE 120^O F.

OTHER PRECAUTIONS:  "FOR INDUSTRIAL USE ONLY"  Do not take internally.  If ingested, DO NOT INDUCE VOMITING.  Consult a physician. 

SECTION X: Hazardous Material Identification System

HEALTH

            0-No Significant Health Risk

            1-Irritation or Minor Reversible Injury Possible

            2-Temporary or Minor Injury May Occur

            3-Major Injury Likely Unless Prompt Action is Taken and Medical Treatment is Given

            4-Life Threatening; Major Permanent Damage May Result from Single or Repeated Exposures

FLAMMABILITY

            0-Materials Will Not Burn

            1-Flash Point Above 200^O F

            2-Flash Point Above 100^O F below 200^O F

            3-Flash Point Between 73^O F and 100^O F

            4-Flash Point Below 73^O F

PHYSICAL HAZARD

            0-Material that are normally stable even under fire conditions and will not react with water.

            1-Material that are normally stable but can become unstable (self-react) at high       temperatures and pressures; may react non violently with water to undergo hazardous polymerization in the absence of inhibitions.

            2-Materials that are unstable; may react violently with water and undergo violent chemical changes with low risk for explosion.

            3-Materials that may for explosive mixtures with water or undergo other chemical change at  normal temperatures.

            4-Materials capable of explosive water reaction, decomposition or polymerization.

Streamer Trainer H.M.I.S.

Health: 0

Flammability: 0

Physical Hazard: 0

THE INFORMATION CONTAINED HEREIN IS BASED ON TECHNICAL DATA WHICH WE BELIEVE TO BE RELIABLE, HOWEVER, SINCE THE CONDITIONS UNDER WHICH THIS INFORMATION MAY BE APPLIED ARE BEYOND OUR CONTROL WE CAN ASSUME NO LIABILITY FOR RESULTS OF ITS APPLICATION.  THIS INFORMATION SHOULD BE USED ONLY BY PERSONS HAVING SUFFICIENT TECHNICAL SKILL TO MAKE INFORMED JUDGEMENTS REGARDING ITS APPLICATION.